Kleenoil Filter Cartridge Service

 

 

The Kleenoil Onboard Oil Recycling System was designed to ensure the effectiveness of continuously cleaning oils used in internal combustion engines and hydraulic systems. During field tests the Kleenoil Onboard Oil Recycling System was entensively used over a five year period in a wide range of engines and hydraulic applications.

Kleenoil Onboard Oil Recycling Systems removes dirt particles to one (1) micron nominal, three (3) microns absolute and absorbs water to less than 0.05% reducing the formation of sulfuric acid.

How to Change a Kleenoil Cartridge

How to Change a Kleenoil Cartridge

In addition to the information derived from an oil sample report, a technician can immediately make the following visual analysis after removing a Kleenoil Filter Cartridge:

  1. As a rule of thumb a cartridge should be replaced after 250 hours of continuous operation.Changing the Kleenoil Filter Cartridge requires much less time than what is required to perform a conventional fluid change. Simply remove the lid from the container to remove the old cartridge. A gray color to the filter outer mesh indicates fuel oil is present in the lubrication system.
  2. An implanted cartridge indicates that the cartridge has absorbed water particulates.

Recommendations:

  • Do not attempt to clean out the filter canister, as the inlet and outlet holes are only 1/8th of an inch in diameter. Place the used cartridge in the new cartridge plastic bag and install a new o-ring and filter cartridge. Torque the lid.
  • Start the engine and run for a few minutes until the canister becomes warm from oil circulation; or test the oil pressure via the oil sample port.
  • When taking an oil sample be sure to clean the sample tube by running the oil through the tube before filling the sample bottle.
  • We recommend a TBN or TAN test be carried out when considering extending engine oil beyond 800 hours.

Edan Farms Testimonial

Edan Farms has been using PowerUp for over 20 years in all our Semi-tractors. We have been a contractor for Fedex Ground running from 20-30 rigs nearly every day. Each truck travels over 200,000 per year.

One of the first things we noticed when we started using PowerUp is that our engines run cooler. Since using PowerUp, we have not had to overhaul an engine in less than 1 million miles and most we haven't overhauled in less than 1.4 million miles. When we do take the engine apart, it is always very clean, and wear is extremely minimal. In 20 years, we have not had a single differential gear failure due to lubrication.

With PowerUp, we extended our oil drains to 30,000 miles and could have probably run further if we had chosen to.

About 10 years ago, because of your presentation on KleenOil Filtration, we started adding these filter units to our engine. With the continuous purification of the oil and complete removal of water, we now have been able to extend oil drains to well over 300,000 miles per rig. We still sample each engine every 30,000 miles and have been very impressed with the condition of the oil even after these extended oil drains. We have never had an issue due to lubrication with any of the engines.

PowerUp and Kleenoil have saved us thousands upon thousands of dollars in oil changes, engine repairs and overhauls. Presumably, though we have never collected the data, we have saved thousands in fuel costs because the engines maintain their efficiency due to very low wear.

I personally maintain our engines and I am a believer in these products because I have seen the results. I would recommend them to anyone. Please feel free to have anyone call if they have any questions.

Eric Schafer
Edan Farms, Inc.
Maintenance Supervisor
330-770-7746

PORTUS INTERMODALES, SA DE CV Testimonial

"We have 15 new buses from Volkswagen that we installed both the Kleenoil oil bypass filter system for the engine oil and and Kleenfuel fuel bypass filter systems on for the diesel fuel system.  There has been a big push as of late on environmental issues in Sonora, Mexico by the State Governor Claudia Pavlovich.  We feel that Kleenoil and Kleenfuel really have a positive impact on the environment.  With both systems installed on each bus, the fuel economy has increased from 2.2 km per liter to 2.7 km per liter.  This is a 22.7% increase in fuel economy!  The 15 buses currently outfitted with both systems are now saving $11,500 USD per month on diesel fuel and $19,500 USD per year on oil change costs.  Furthermore, on lubrication we are now saving 80% on lubricants and down time.  This savings directly impacts our bottom line and is a great benefit to the environment due to the fact that we are now recycling our oil and burning cleaner fuel!  Our plan is to keep outfitting our fleet with Kleenoil and Kleenfuel products until we have 100% of our fleet outfitted with both systems.  The people from COMSA are handling the cartridge changes for us as well as the oil sampling that is sent to the third party lab for testing.  We have been very pleased with the results!"

Lic. Enrique Medesigo Vite, General Manager, Sonora, Mexico

 

Energy Drilling Testimonial

"We were changing our engine oil on our drilling rigs every 250-500 hours depending on the type of engine.  When we tested the new Kleenoil filter system, we still had good oil at 5000 HOURS and made the decision to use the Kleenoil filter systems on all of our engines. We now change our oil at 2000 hours and have extended our oil life 8 times.  Based on ISO standards, our oil at 1000 hours is better than new oil.  One big question is how this affects warranties?  None of these practices will affect our warranty."

Pat Burns, Jr, General Manager Energy Drilling Company, Natchez, MS

DH Griffin Wrecking Co. Testimonial

The Kleenoil systems are increasing my equipment reliability, reducing downtime thereby increasing my production.

Kent Baltzer, DH Griffin Wrecking Co.

Larry Morris Trucking Testimonial

Our trucks have crossed over 140,000 miles on the same oil and is cleaner than brand new oil and getting cleaner every day! The oil and maintenance savings I have incurred easily covers the cost of the Kleenoil systems!

Larry Morris, Owner, Larry Morris Trucking